Biofuels run into trouble: John Kemp

-- John Kemp is a Reuters columnist. The opinions expressed are his own --

By John Kemp

LONDON (Reuters) - Despite a promising start, the U.S. experiment with renewable fuels is facing a serious challenge next year. Falling gasoline consumption, lower pump prices and contradictions within the federal government program are intensifying existing pressures on ethanol distillers and farmers already struggling to cope with over-capacity and collapsing margins.

ETHANOL ENTHUSIASM

Between 2000 and 2007, production of fuel ethanol quadrupled from 1.6 billion to 6.5 billion gallons, and the industry is on course to distil a record 9.3 billion gallons in 2008.

Ethanol production is not really economic at oil prices below about $60-70 per barrel (prices of grains and fats for ethanol conversion and processing costs are too high relative to oil). So the original boost to ethanol came from its use as an oxygenating additive in reformulated gasoline, rather than as fuel in its own right, when a number of states banned the use of MTBE.

As oil prices breached $50 in late 2004 and continued to climb steadily higher over the next four years, ethanol's properties as a fuel suddenly became more attractive. Blenders began to use ethanol as a cheaper (partial) substitute for conventional oil-derived blendstocks in making gasoline.

Prompted by national security concerns and encouraged by lobbyists for the farm sector, U.S. legislators tried to accelerate the use of ethanol by mandating a minimum ethanol content for all gasoline produced or imported into the United States.

The centerpiece of the government's intervention is the Renewable Fuel Standard (RFS) which sets a steadily increasing minimum volume of ethanol that must be blended into the nationwide gasoline supply each year.

The original RFS set out in the 2005 Energy Policy Act was relatively modest -- requiring blenders to incorporate 4 billion gallons of ethanol into the fuel supply in 2006, rising to 5.4 billion gallons in 2008 and 7.5 billion gallons by 2012.

But as soaring crude oil prices intensified concerns about energy dependence, the 2007 Energy Security and Independence Act imposed a set of much more ambitious targets. The RFS blending target for 2008 was almost doubled to 9 billion gallons, rising to almost 13 billion gallons in 2010 and to an extraordinary 36 billion gallons in 2022 (see chart here).

WORSENING ECONOMICS

Most attention has focused on the role of the RFS, but surging oil prices were probably more important in supporting ethanol.

RFS is designed to stimulate investment in the production facilities and distribution infrastructure needed for ethanol by guaranteeing a minimum level of demand for the fuel irrespective of oil prices. But over the last three years, RFS has never been binding.

On a purely voluntary basis, gasoline blenders have always used more ethanol than the required minimum because increasingly high oil prices made ethanol an attractive fuel in its own right.

RFS mandated 4 billion gallons of ethanol in 2006, but blenders actually used 4.9 billion. It mandated 4.7 billion in 2007, when blenders actually used 5.7 billion (an extra billion gallons or 22 percent).