October 24, 2018 / 1:01 AM / a month ago

RPT-COLUMN-Alumina squeeze hits already slowing global aluminium growth: Andy Home

(Repeats without changes)

* Global aluminium output growth: tmsnrt.rs/2OIJLK5

By Andy Home

LONDON, Oct 23 (Reuters) - Global aluminium production growth has ground to a halt this year.

Cumulative production grew by just 0.3 percent in the first nine months, the slowest rate of expansion since the Global Financial Crisis (GFC) in 2008-2009.

Smelter outages in Canada and Brazil continue to constrain run rates in the Western World, while structural reform in China is capping output in the world’s largest aluminium producing nation.

In theory, the potential exists for a re-acceleration in growth in both China and the rest of the world.

In practice, however, a squeeze on availability of alumina, the raw material used to make aluminium, is compressing smelter margins with the rising threat of more production hits.

Graphic on global aluminium output growth:

tmsnrt.rs/2OIJLK5

UPS AND DOWNS

Aluminium output in the world outside of China grew by 1.9 percent in Jan-Sep 2018, according to the International Aluminium Institute (IAI).

Asia (excluding China) is the region with the fastest production growth at 14.0 percent so far this year largely thanks to the ramp-up of new capacity in India.

Vedanta Resources reported record production of 494,000 tonnes in Q3, up 23 percent year-on-year, as the company’s Jharsuguda II plant builds up towards its 1.25-million tonne-per-year capacity.

The plant’s third line was operating 303 out of 336 pots by the end of September with the fourth line remaining “under evaluation”, the company said.

Restarts in the United States are also building momentum but their impact on regional output is being mitigated by the continuing strike action at Alcoa’s Becancour smelter in Canada.

Only one of the plant’s three production lines has been operational since a lock-out of union members in January. Output in the third quarter was just 32,000 tonnes, compared with 113,000 tonnes in the year-earlier period, according to minority owner Rio Tinto.

Also continuing to operate at just 50-percent of its 450,000-tonne per year capacity is the Albras smelter in Brazil.

Norway’s Hydro has cut output at Albras to align it with the company’s Alunorte alumina refinery, which has also been operating at 50 percent of capacity since February due to environmental concerns.

ALUMINA SQUEEZE

The continuing loss of production from Alunorte is roiling the alumina market, keeping prices elevated and squeezing operating margins for smelters without their own integrated raw material pipeline.

The consequent threat to aluminium production is likely to counteract the resolution of one-off supply disruptions at the likes of Becancour and Albras.

Alcoa has just announced the start of a consultation process to lay off workers at its Aviles and La Coruna smelters in Spain.

Both have been struggling with what the company called “structural issues”, operating below combined 180,000-tonne per year capacity for several years.

Alcoa intends to restructure production around its third smelter in Spain, the 230,000-tonne per year San Ciprian plant, which it pointedly noted “produces both alumina and aluminum”.

The Mostar smelter in Bosnia is another European smelter facing closure due to both rising alumina and power prices.

The government is actively working on a financial lifeline for the indebted plant but it is currently operating on a “warm regime”, running at minimal levels to keep the pots warm enough to allow for a future production restart.

NO GROWTH IN CHINA

Aluminium production in China fell by 0.7 percent over the first nine months of the year, according to the IAI.

This is not the same picture painted by the official figures from the National Bureau of Statistics but that’s why the IAI switched its methodology on Chinese production at the start of the year.

The IAI’s estimate that China produced 27.18 million tonnes in January-September is 2.18 million tonnes higher than the official count.

The IAI’s estimates capture a pick-up in run-rates over the last three months but a highly modest one and not yet sufficient to push this year’s output up to last year’s levels.

Key to understanding what is happening to China’s giant aluminium sector is the structural reform programme enacted by Beijing over the last couple of years.

New capacity has been blocked or allowed only in exchange for the closure of older plants.

Illegal capacity has been ordered closed, while smelters are increasingly prone to the same environmental pressures being applied to the rest of China’s industrial base.

A plan to raise fees on onsite power plants is causing more headaches for a sector that has expanded smelter capacity on the back of such “captive” power.

And, like their Western counterparts, Chinese smelters without vertically integrated alumina supplies are also suffering margin compression.

China’s unusually high exports of alumina to the international market doesn’t mean it’s not short itself.

Indeed, this will be a year of alumina deficit in both China and the rest of the world, a very rare market development.

The combination of structural reform, environmental crackdown and margin squeeze is going to continue constraining national aluminium production, according to research house CRU, which is forecasting output growth of just 0.5 percent this year.

FILLING THE SUPPLY GAP

None of which has stopped the flow of Chinese aluminium in the form of semi-manufactured products to the international market.

Indeed, exports of unwrought aluminium surged by 17.5 percent in the first nine months of this year.

This, however, is a direct consequence of China’s defence against U.S. tariffs, particularly those on aluminium.

Beijing has lifted the rebate on value added tax (VAT) on some aluminium product exports to 16 percent from 13 percent. Given VAT stands at 17 percent, this amounts to a near tax-free export option.

The rest of the world needs this metal to fill its own aluminium deficit.

It also needs the cushion of the inventory that has accumulated during the years of over-production since the GFC.

Because with CRU estimating that some 40 percent of smelters are losing cash at current metal-alumina price levels, global production growth is not going to recover in any meaningful way soon.

And that’s assuming a lifting of U.S. sanctions against Russian producer Rusal.

The sanctions deadline has been extended again to Dec. 12 and the market’s collective assumption is that the latest roll-over is a sign of a pending peace deal.

However, as Swedish smelter Kubal has just warned, if sanctions aren’t lifted, it will mean more disruption to the aluminium supply chain.

Editing by Alexandra Hudson

0 : 0
  • narrow-browser-and-phone
  • medium-browser-and-portrait-tablet
  • landscape-tablet
  • medium-wide-browser
  • wide-browser-and-larger
  • medium-browser-and-landscape-tablet
  • medium-wide-browser-and-larger
  • above-phone
  • portrait-tablet-and-above
  • above-portrait-tablet
  • landscape-tablet-and-above
  • landscape-tablet-and-medium-wide-browser
  • portrait-tablet-and-below
  • landscape-tablet-and-below